Molecular integrity of monoclonal antibodies produced by hybridoma cells in batch culture and in continuous-flow culture with integrated product recovery.

The molecular integrity of monoclonal antibodies (MCAB) produced by murine hybridoma cell line TB/C3 was studied in batch and continuous-flow cultures. In batch culture, one band of MCAB was detected initially by Western blotting of sodium dodecyl sulfate (SDS)-polyacrylamide gels run under unreduced conditions, but heterogenous MCAB bands appeared as the culture aged. The latter were due to the degradation of MCAB by proteases active at the neutral pH of the culture. The deleterious effect of proteases was minimized in the continuous-flow cultures which were integrated for product recovery. The MCAB of high quality was purified over 26 days from a culture grown at a dilution rate of 0.025 h(-1) (experiment 1). However, at a lower dilution rate of 0.015 h(-1) (experiment 2), the integrity of MCAB was compromised after the initial 13 days of culture. This was shown to be due to the variation in the carbohydrate content of MCAB produced, as judged by the increased sialylation of heavy chains and the varied reactivity of MCAB with lectins (Maackia amurensis agglutinin, Galanthus nivalis agglutinin, and Datura stramonium agglutinin) as the age of the culture increased. The concentration of the purified MCAB samples by enzyme-linked immunosorbent assay (ELISA) (used normally) was usually higher than that estimated by absorbance at 280 nm. Best correlation between the two methods (ELISA-280 nm ratio of 1.02-1.25) was obtained with experiment 1 samples. This ratio increased in experiment 2 and batch culture samples as the heterogeneity of MCAB produced increased, being 1.03-2.94 and 2.53-4.62, respectively. Therefore, ELISA overestimated MCAB concentration when the molecular integrity of the latter was compromised. The ELISA-A(280) nm ratio might hence provide a useful indicator for assessing the quality of MCAB produced. Comparison of SDS-polyacrylamide gels stained with Coomassie Brilliant Blue R and silver showed that the former correlated better with the MCAB activity stain, whereas the silver stained both the protein- and carbohydrate-rich components. Comparison of the patterns produced with these two stains might therefore offer another parameter to monitor the overall integrity of MCAB produced. Finally, the data presented have important implications on the validity of using long-term and intensive cultures for generating MCAB because such cultures would be subjected to the additive effects reported for batch and continuous modes of growth.